Hayward W3H135FDP H-Series Propane Pool Heater User Manual

1. Увод

This manual provides essential information for the safe and efficient installation, operation, and maintenance of your Hayward W3H135FDP H-Series Propane Pool Heater. Please read this manual thoroughly before attempting to install or operate the heater. Keep this manual for future reference.

The Hayward H-Series heater is designed for heating above-ground pools using propane gas. It features a durable cupro nickel heat exchanger, an intuitive electronic control panel, and forced-draft combustion for reliable performance in various weather conditions.

Фронт view of the Hayward W3H135FDP H-Series Propane Pool Heater, highlighting its 135,000 BTU capacity, propane fuel type, and suitability for above-ground pools.

2. Важне информације о безбедности

УПОЗОРЕЊЕ: Неправилна инсталација, подешавање, преинаке, сервис или одржавање могу узроковати оштећење имовине, повреде или смрт. Пажљиво прочитајте упутства за инсталацију, рад и одржавање пре инсталирања или сервисирања ове опреме.

• Увек искључите напајање пре сервисирања.
• Осигурајте одговарајућу вентилацију око грејача.
• Немојте складиштити нити користити бензин или друге запаљиве паре и течности у близини овог или било ког другог уређаја.
• Инсталацију и сервис мора обавити квалификовани инсталатер, сервисна агенција или добављач гаса.
• Овај грејач је дизајниран за propane gas only. Do not attempt to use natural gas.
• Држите децу и кућне љубимце даље од грејача.

3. Садржај пакета

Verify that all components are present before beginning installation. If any parts are missing or damaged, do not proceed with installation and contact Hayward customer support.

• Hayward W3H135FDP H-Series Propane Pool Heater unit
• Кориснички приручник (овај документ)
• Installation hardware (specific items may vary, refer to packing list)

4. Подешавање и инсталација

Installation must comply with all local codes and ordinances. In the absence of local codes, refer to the National Fuel Gas Code (ANSI Z223.1/NFPA 54) or the Natural Gas and Propane Installation Code (CSA B149.1).

4.1 Захтеви за локацију

• Install the heater outdoors, on a level, non-combustible surface.
• Maintain adequate clearances from combustible materials and other equipment. Refer to the heater's data plate for specific clearance requirements.
• Ensure the location allows for proper ventilation and drainage.
• Avoid locations where the heater may be exposed to excessive wind or spray from the pool.

4.2 Водоводне везе

Connect the heater to your pool's filtration system. The heater should be installed after the filter and before any chemical feeders.

• Користите одговарајуће водоводне арматуре и заптиваче да бисте спречили цурење.
• Ensure proper water flow through the heater. Insufficient flow can cause damage.

Сиде view of the heater, illustrating the plumbing inlet/outlet and the forced-draft combustion system.

4.3 Gas Connections (Propane Only)

ВАЖНО: This heater is factory-set for propane gas. Do not attempt to convert it to natural gas. Gas connections must be made by a qualified professional.

• Connect the propane supply line to the heater's gas inlet.
• Ensure all gas connections are tight and leak-free. Use a leak detection solution to check for leaks.
• Install a manual gas shut-off valve upstream of the heater.

4.4 Електричне везе

Electrical wiring must be performed by a qualified electrician in accordance with all local codes and the National Electrical Code (NFPA 70).

• Уверите се да је грејач правилно уземљен.
• Connect the heater to a dedicated circuit with appropriate overcurrent protection.

5. Упутство за употребу

5.1 Прво покретање

1. Ensure the pool pump is running and there is adequate water flow through the heater.
2. Open the manual gas shut-off valve to supply propane to the heater.
3. Turn on the electrical power to the heater.
4. The electronic control panel will illuminate.

5.2 Подешавање жељене температуре

Use the intuitive electronic control panel to set your desired pool temperature.

1. Press the "Mode" button to select the pool heating function.
2. Use the up/down arrow buttons to adjust the target temperature.
3. The heater will automatically ignite and begin heating the water to the set temperature.

The electronic control panel for setting and monitoring pool temperature.

5.3 Shutting Down the Heater

1. To temporarily stop heating, turn off the heater via the control panel.
2. For extended shutdown or servicing, close the manual gas shut-off valve and turn off the electrical power to the heater.

6. Одржавање

Regular maintenance ensures optimal performance and longevity of your Hayward H-Series heater. Always disconnect power and gas supply before performing any maintenance.

6.1 Рутинске провере

• месечно: Inspect the area around the heater for debris, obstructions, or signs of leaks.
• Seasonally: Check the heat exchanger for scale buildup or corrosion. If necessary, clean according to manufacturer guidelines or consult a qualified service technician.
• Ensure proper water chemistry in your pool to prevent damage to the heater's components.

6.2 Зимовање

In areas subject to freezing temperatures, proper winterization is crucial to prevent damage.

1. Turn off the heater and disconnect both electrical power and gas supply.
2. Drain all water from the heater's plumbing and heat exchanger. Use a shop vacuum or air compressor to ensure all water is removed.
3. Store the heater in a dry, protected area if possible, or cover it with a weather-resistant cover.

КСНУМКС. Решавање проблема

Пре него што контактирате корисничку подршку, поновоview следећи уобичајени проблеми и решења.

If troubleshooting steps do not resolve the issue, contact Hayward customer support or a qualified service professional.

8. Спецификације

• Модел: W3H135FDP
• Врста горива: Пропан гас
• БТУ улаз: 135,000 БТУ/сат
• Топлотна ефикасност: 82%
• Измењивач топлоте: Cupro Nickel
• Димензије (Д к Ш к В): Приближно 30.3 к 21.4 к 22.6 инча (77 к 54.4 к 57.4 цм)
• Тежина артикла: Приближно 117.5 лбс (53.3 кг)
• Електрични захтеви: Refer to product label for specific voltagе и ampераге.
• Емисије NOx: Low NOx (meets clean air quality standards)

Product dimensions and weight for the Hayward W3H135FDP H-Series Pool Heater.

Разно views of the Hayward W3H135FDP H-Series Pool Heater, illustrating its design from different angles.

9. Гаранција и подршка

Hayward provides a limited warranty for its products. For specific warranty terms and conditions, please refer to the warranty card included with your product or visit the official Hayward webсајту.

For technical assistance, parts, or service, please contact Hayward customer support:

• Webсајт: ввв.хаивард.цом
• Телефон: Refer to the Hayward webсајт за регионалне контакт бројеве.

When contacting support, please have your model number (W3H135FDP) and serial number ready.